Disconnect the electrical connections located to the left side of the heater box. I then installed the two bolts and two nuts supporting the center to the floor and completed the installation by securing the five screws on the top. Shop O'Reilly Auto Parts for a replacement climate control module for your Dodge Ram, as well as blend door or vent door actuators, blower motor resistors, and more to make your repairs and keep your truck comfortable. I also inspected the blend doors for wear and tear and proper operation. Once the thermostat had opened, I began to take temperature readings. Toyota vent selector not working. His caption stated, "My toes went numb about an hour ago. " No idea where to find this piece or what the part number is.
Truth is, it is one of those jobs that no person who has ever done it before would rightfully volunteer to do. Open the glove box and press "in" toward the center on each side and lift the glove box out of the dash assembly. How can i get the air just to front dash air vents. Anyone have issues with air vents not working correctly? The new Garrett turbochargers are looped through the heater core and that raised some concerns as to the amount of coolant they were receiving across the bearings. Air Vent Selector Not Working?: the Blower Control Works Fine but. So why haven't I replaced them? Remove the two screws holding the center plastic cover for the SRS.
As I mentioned earlier, note the pine needles blocking airflow. Repositioning the dash assembly worked best for me with two pairs of hands. Editor's note: The Geno's folks are sending Scott a Cab Fresh Filter Kit to cover the outside air inlet grid and prevent the messy pine straw and debris problem in the interior of the truck. Two are behind the ECU, one holds the AC condenser bracket and the other is located above the rear valve cover. Blower doesn't blow very well. There is an excellent write-up on these doors and how to replace here: My heater controler is stuck on vent and won't go back to defrost on mt 2010 ram 1500 so can you please tell me haw to fix the problem please. Here are the steps I used: - Disconnect the negative battery cables. See editor's notes at the end of this article. Strap the dash up and out of the way. Release the A/C supply and return quick disconnects.
Remove the screws securing the heater core to the upper half. Lift the driver's side off of the 13mm bolt and allow the dash assembly to rest on the steering column. No heat on the floor turned out to be a broken actuator coupler. The dash assembly can now be rotated toward the seat. Heat won't transfer from vent to floor when put on floor heat blows from defrost. Remove the five screws where the dash meets the windshield interior cowl. Details, details, the gear indicator cable. 2006 dodge ram vent selector not working. Be sure to put a drain pan under the truck to catch the engine coolant.
Remove the heater core. If the climate control module on your Ram is damaged or failing, then you may find that your A/C or heat aren't working, that the temperature will not change, or that the vent position cannot be adjusted. If you have air flowing only through the vents with no defrost or floor, this door is failing. Loosen the two bolts on the driver's and passenger's sides of the dash. Reassemble the upper and lower half, making sure the blend doors are in their respective mounting holes and move freely. The box is out of the truck! I did notice this summer when I ran the A/C that it didn't blow overly hard but now that its real cold out I know its not blowing hard enough. The mechanical swivel unit. Make sure the heater, A/C and vacuum lines are all in place prior to securing the box. Is there a way to know how hard it should blow? Remove the triangular shaped panels below the dash on both the driver and passenger's side, exposing the 13 mm bolts that hold the dash assembly on each side. Finally I measured the discharge air temperature with the heat on maximum, 134°! On this vehicle, there are two mode door actuators, one for the defroster and the other for the floor and panel vents. Dodge ram vent selector not working mom. I've had the parts to replace both the heater core and the air conditioning evaporator for a few years now, both purchased from Geno's Garage.
I carefully put a bead of silicone around the penetrating holes on the inside of the firewall for the heater core, A/C evaporator and box drain and slid the heater box assembly back into place. It's stuck in the vent position and can't shift to the floor position. One method suggests using an aftermarket heater core that has a mechanical swivel connection on the supply and return tubes. Disconnect the 1/2" and 5/8" A/C lines using a special tool available from most auto parts stores. Use OEM replacement parts.
Heater core installed. The Geno's guys sent me a Cab Fresh exterior filter kit to keep the heater box clean going forward. Then I attached the steering column and the shift indicator cable. Drop the steering column down and rest it on the seat. It can also control the climate control actuators below the dash that make the adjustments as needed to reach the desired vent position or temperature. A/C evaporator installed. Where is the activater that switch from defrost to floor. Bless YouTube for a plethora of "coming attractions" showing the steps to get the job accomplished. Can you say "blocked air flow?
Engine Side of the Firewall. This can affect the comfort of your cabin, and may also affect the control of your blower motor or activation of the A/C compressor. Remove the safety collars. Had I not pulled the heater box and disassembled it, I would have not found the pine needles blocking the air flow and I would not have received the full benefit of the labor-intensive repair.
Mode Door 2: When mode door 1 is set to divert air away from the vents and into the second stage of the system, door #2 chooses whether air goes to the defrost vents to the windshield or out through the floor vents in the passenger and driver's side footwells. My heat only comes from the vents and and when I change to defrost or floor it doesn't happen. Remove the engine coolant supply and the return hoses attached to the heater core by removing the clamps and working them free. Using this core will allow the installer to remove and replace the core without removing the heater box. I even rolled up my car blanket and put it away. Separate the upper and lower half of the heater box assembly and remove the A/C evaporator. Disconnect the vacuum lines located to the right of the heater box assembly. I found it was easiest to lift the dash onto the two 13mm bolts and roll it up toward the windshield. My blower for the heater doesn't seem to blow very hard even on high. This actuator is responsible for air flow direction.
Is there a more powerful blower motor I could swap in? A/C oil added to the system. The first one has a ground wire attached and has two nuts. After 19 years of service, Red Ryder's tubes were flattened and the corrosive effect of electrolysis had taken its toll. Do not remove the bolts at this time.
In my years with Turbo Diesels, faster methods do not always equal a quality job. The balance of this winter is going to be much more comfortable. Remove the knee panel below the steering column. Everything else seems correct, but won't stop blowing air from defrost when it's on floor only.
Using pliers, pull straight up first on the control rod, then pull up on the cable support bracket. If you do not have the ability to refill the refrigerant you can have the local shop do it later. You will first need to evacuate the 134 from the system (or you can have a shop do it for you). In all, it is a job definitely worth doing, just not one I would want to do again anytime soon. I think it makes good sense to do the job once and do it right. It's what the actuator slides into that moves the blend door. Failure is indicated by an inability to choose between defrost and floor. While one person holds the dash up against the front mounting holes, the other person tightens the two 13mm bolts. Remove the screws securing the upper and lower half of the heater box.
Knowing all of this, I talked myself into getting it done. Shift the transfer case into four-wheel low. Both methods eliminate all of the steps necessary on the engine side of the firewall (A/C lines, computer, vacuum line, heater box nuts). With the new core pushed firmly in place, install the brackets and ground strap. The control knob just turns freely and does nothing what can I do to fix it. The second is in the upper right hand corner behind the glove box, facing up.
TALKING POINT: Carlton made a surprise call to leave out marquee star Tayla Harris for their win over lowly Geelong and ended up kicking their highest score of the season. INJURIES: B McKay (NM, knee), S Switkowski (Frem, concussion), L Ryan (Frem, ankle), C Weightman (WB, broken collarbone), L Vandermeer (WB, hamstring), T O'Brien (WB, calf), J Bews (Geel, concussion), R Bonner (PA, ankle), D McStay (Bris, ankle), D Butler (StK, Achilles), J Martin (Carl, calf), L Murphy (Adel, neck). Enter co-captain Brianna Davey, who stood tall with 11 third-quarter disposals in a total of 28 as she helped spark the Magpies into life. After starting with just eight teams in 2017, clubs who initially dismissed the idea of a women's team have pushed the league to expand at a rapid rate. THE MOMENT: Richmond were able to seal a stunning upset over Brisbane but the Lions almost pinched it. After six seasons of playing through the heat of summer, the league has shifted to an August start, during the pre-finals bye for the men, and will finish with a grand final in December. WHAT'S NEXT: In the highlights of round two, Melbourne take on North Melbourne ahead of the Demons' AFL qualifying final in a tantalising clash.
Embattled Essendon will celebrate the club's 150th anniversary in a Friday night showdown with rivals Carlton. PLAYER OF THE ROUND: Melbourne lost a second-straight match but captain Max Gawn could not have done any more to get the Demons over the line. The Dockers' most recent loss before that was to Carlton in the 2019 preliminary final. Toogood collected two goals for the game. INJURIES: Mikayla Western (WC, elbow), Chelsea Randall (Adel, lip/ankle), Mackenzie Eardley (Haw, wrist), E O'Driscoll (Frem, hand). TRIBUNAL WATCH: A quiet week for the match review officer in round nine. STATS THAT MATTER: Brownlow Medal favourite Patrick Cripps has registered at least 30 disposals and a goal in six games this season. BRISBANE, AUSTRALIA - NOVEMBER 27: Sarah Lampard, Eliza West and Tyla Hanks of the Demons pose for photos with fan during the AFLW Grand Final match between the Brisbane Lions and the Melbourne Demons at Brighton Homes Arena on November 27, 2022 in Brisbane, Australia. The Tigers smashed the drought by surging past Geelong, singing the song loud and proud on the Cats' home ground. Geelong host North and Collingwood play the Bulldogs in the elimination finals.
TALKING POINT: So, can Nathan Buckley coach or not? WHAT'S NEXT: Sydney kick off round 12 on Thursday night when they host the Western Bulldogs at the SCG and Melbourne clash with Collingwood on Queen's Birthday Monday in the last match of the round. The Cats are hopeful their spearhead will escape with a fine despite the AFL crack down. Read our Privacy Policy. Natalie Wood was unveiled as the inaugural Essendon AFLW senior coach in March this year, followed by Georgia Nanscawen, who became the first ever AFLW Bomber. INJURIES: M Bontempelli (WB, ankle), C Salem (Melb, knee), D Presitia (Rich, hamstring), M McGovern (Carl, back/hip), J Cameron (Geel, hip), K Langford (Ess, hamstring), C Laverde (Ess, hip), D Zorko (Bris, Achilles), X Duursma (Port, collarbone), T McKenzie (Port, knee). But the Crows will have to do it without the most decorated player in league history after Erin Phillips opted to switch to crosstown rivals Port Adelaide, the club who her father Greg was a legend with in the SANFL. 1 draft pick Montana Ham went to ground and immediately clutched at her knee in the dying stages of the Swans' loss to St Kilda. Photo by Albert Perez/AFL Photos). TRIBUNAL WATCH: Giants defender Pepa Randall could be assessed by the match review officer for a first-quarter sling tackle on the Bulldogs' Richelle Cranston. Prespakis' effort was even more meritorious for the fact she suffered a heavily corked thigh during a practice game and didn't train for a fortnight in the build-up to round one, passing a fitness test on the eve of the game. THEY SAID IT: "It's a signature win for the club" - Carlton coach Michael Voss after he began his tenure at the Blues by overseeing the club's round-one win over Richmond - the first time in a decade they have opened their season with a victory over the Tigers. Hawthorn coach Bec Goddard on the quarter-time spray that spurred the Hawks to a breakthrough win over Sydney. TRIBUNAL WATCH: Collingwood pair Jordyn Allen and Sophie Casey face scrutiny from the match review officer after incidents in the Magpies' crucial win over Richmond.
Weekend Papers + Everyday Digital. After three barren seasons, not only are the Tigers in their first finals series, but they took fourth from North and Geelong to secure the double chance. The Brisbane Lions are at home to St Kilda on Saturday night in a battle for top-four supremacy, while Melbourne will be desperate to rebound from back-to-back losses in their traditional Queen's Birthday clash with Collingwood. Richmond's Beth Lynch is in trouble for a tackle that sidelined Geelong opponent Rachel Kearns with a shoulder injury. TRIBUNAL WATCH: Richmond's Rhyan Mansell was hit with a one-match ban for striking Jack Ginnivan in the back of the head but GWS forward Jesse Hogan escaped sanction for the accidental high contact that left Jed Bews concussed. The Bombers would run out in their inaugural Pride guernsey in round eight, designed by VFLW Premiership players Mia-Rae Clifford and Kendra Heil. PLAYER OF THE ROUND: Adelaide ball-magnet Ebony Marinoff had a huge say in her side's hard-fought 14-point win over North Melbourne, racking up a game-high 29 disposals, 13 tackles, seven inside-50s and six clearances. WHAT"S NEXT: There will be one finals spot up for grabs in the last round of the season next weekend. Unlimited access to breaking news, sport, business, lifestyle and in-depth exclusives home delivered or direct to your device. Danielle Ponter kicked four goals as the Crows fell just one point short of the Western Bulldogs' competition-record high score. TRIBUNAL WATCH: Port Adelaide's Maria Moloney will come under scrutiny for the tackle that had Essendon youngster Lily-Rose Williamson stretchered off in a neck brace. It was Antonio's first game of the season and her 50th AFLW appearance. Despite missing six matches after taking personal leave, Martin showed more than enough to have Richmond supporters excited about what he can do for the rest of the season.
Melbourne coach Mick Stinear after his Demons downed reigning premiers Adelaide in a reversal of last season's grand final result. Cross-town rivals Sydney and GWS will face off for the first time as Brisbane and Gold Coast contest the Q-Clash. STATS THAT MATTER: In the AFL era, no team has sat inside the top-eight all season before falling out in the final round. Sunday's Collingwood-Adelaide clash should be a beauty but the final game of the round shapes as the best of the lot, with flag contenders Melbourne and Brisbane set to lock horns at Casey Fields. Cripps was best afield again when he racked up 35 disposals and two goals to lead Carlton to their 48-point win over Adelaide on Sunday. Photo by Matt Roberts/AFL Photos).
A look ahead to the seventh season of AFLW, with four teams entering the league just 138 days after Adelaide won the last grand final in April. WHAT'S NEXT: Adelaide's clash with North Melbourne looks the pick of the bunch, while unbeaten Geelong can show how their form stacks up when they face Collingwood. The number of Brownlow votes that Geelong's Patrick Dangerfield should already have. KEY MOMENT: Collingwood's perfect season record was under serious threat when they were goalless and trailed the Bulldogs by two points at half-time. STATS THAT MATTER: A crowd of 12, 092 at Marvel Stadium on Saturday night justified the round-one fixture between Essendon and Hawthorn being moved from the smaller ETU Stadium - also known as North Port Oval - after a "#MoveItToMarvel" campaign led by Hawks coach Bec Goddard. The incident resulted in a free kick but Xenos was not reported on the spot. TALKING POINT: Round 10 was outstanding, with Melbourne going within a whisker of snatching top spot and Richmond winning the three-way duel between themselves, North and Geelong for fourth place. STATS THAT MATTER: It's not a stat Fremantle will want to remember. WHAT'S NEXT: Thursday's public holiday brings a Western Derby to kick off round five before a flurry of action in Melbourne on Friday. As Bulldogs coach Nathan Burke noted post-match, it really can be a cruel game.
Round four was the Dons' first Dreamtime game, assistant coach Kirby Bentley hand painted every players' boots to represent a unified team, and Essendon released their first ever Indigenous guernsey designed by two students from Thornbury Primary School. THE MOMENT: Melbourne pocket rocket Kysaiah Pickett pounced on the crumbs from a marking contest and snapped the winning goal under pressure in the dying seconds of Saturday night's five-point victory over Carlton. It's also the fourth game in a row where they've held the opposition scoreless in the first quarter. Goss's long kick on the final siren from just outside the 50-metre arc was spoiled by a Power defender and the ball stopped just short of the goal line. On Sunday, Melbourne turned the screws on St Kilda early and rode a third-quarter challenge to win comfortably against a side pushing for a top-four spot. Both were instrumental in their side's comeback win over Carlton, which confirmed the Tigers' spot in the AFLW finals for the first time. Picture: Getty Images. THEY SAID IT: "It's great to be on top of the ladder - it means we've won again - but realistically, it doesn't change anything, " Greater Western Sydney coach Leon Cameron, keeping a lid on things after the Giants defeated Essendon to go top for the first time in the club's history.
The Blues had been on the verge of confirming their finals spot when Charlie Curnow's goal gave them an eight-point lead just minutes earlier. Stream them all for free on 7plus >>. The 19-year-old forward's calm set shot from 40 metres ultimately decided a thrilling contest. TALKING POINT: Carlton entered the season as equal premiership favourites but the Blues' flag dreams already appear shot after slumping to a 2-3 record. North Melbourne caretaker coach Leigh Adams said Cunnington's return gave his side an emotional lift at the end of a tough season, in which they will likely be handed the wooden spoon. It's tough for the club and the players and our supporters and we understand the frustration" -mWest Coast coach Adam Simpson on his club's worst start to an AFL season, 1-11. Essendon will have their first taste of playing an original AFLW team when they take on Carlton. The Brisbane-Collingwood and North Melbourne-Richmond clashes will both have significant top-eight ramifications. We'll aspire to function the way they are at the moment. "